[표지]
목차
CO2 free 친환경 냉온열전력 삼중에너지 생산 시스템 공동 개발 1
제출문 2
보고서 요약서 3
국문 요약문 4
영문 요약문 5
목차 6
제1장 과제의 개요 7
제1절 연구배경 7
제2절 개발기술의 중요성 및 필요성 9
제2장 국내외 기술 개발 현황 12
제1절 태양열광(PVT) 기술소개 및 선행연구 분석 12
제2절 공기식 지중열교환기(GAHX) 기술소개 및 선행연구 분석[원문불량;p.14] 19
제3장 연구 수행 내용 및 결과 37
제1절 태양열광(PVT) 단위모듈 개발 37
제2절 공기식 지중열교환기(GAHX) 단위모듈 개발[원문불량;p.56-57,75-76] 53
제3절 9kWt급 삼중에너지 생산 시스템 실증단지 개발 84
제4절 9kWt급 삼중에너지 생산 시스템 실증단지 구축 109
제5절 9kWt급 삼중에너지 생산 시스템 실험 125
제6절 삼중에너지 생산 시스템 AI(ANN, FL) 제어 기법[원문불량;p.136,138] 139
제7절 삼중에너지 생산 시스템 경제성 및 온실가스 저감 평가 155
제8절 소결 179
제4장 연구목표 달성도 및 성과 181
제5장 연구개발 성과 활용 계획[원문불량;p.181] 183
제6장 연구개발과제 수행에 따른 연구실 안전 조치 이행 실적 188
제7장 연구개발과제의 대표적 연구 실적 190
[참고문헌] 191
CO₂ Free Trigeneration Technology 193
COPYRIGHT 194
Disclaimer 194
Acknowledgments 195
Acronyms 196
Executive Summary 198
Contents 209
1. Introduction 217
1.1. Microgeneration and Trigeneration Systems 217
1.2. Objectives 219
2. Case Studies and Analysis Methodologies 221
2.1. Case Studies 221
2.2. Testing of Trigeneration System at Twin-Test-Cell 223
2.3. Simulation and Analysis Methodology 224
2.4. Simulation Assumptions and Control Strategies 226
3. Results and Discussions: System Design and Performance Potential Evaluation 228
3.1. Energy Analysis Results 228
3.2. Emission Analysis Results 235
3.3. Cost Analysis Results 237
4. Results and Discussions: Model Validation and System Field-Assessment at Twin-Test-Cell 243
4.1. Validation of TRNSYS Component Models 243
4.2. Assessment of Twin-Test-Cell Experiment Setup 255
4.3. Development of Twin-Test-Cell Testing Scenarios and Schedule 255
4.4. Experimental Test and Simulation of Trigeneration System and Heat Pump System at TTC 257
4.5. Evaluation of TTC Trigeneration System Performance with Respect to Conventional Boiler-Chiller System 261
5. Application of Advanced Control Strategies and System Optimization 265
5.1. Comparative Study of Fuzzy Logic Based Controllers 265
5.2. Optimization Trigeneration System Study 272
6. Summary and Conclusions 285
7. General Guidelines and Recommendations 291
8. Further Work 293
9. References 294
Appendices 300
Appendix A. Twin-Test-Cell Facility 300
Appendix B. TRNSYS Component Models 304
Appendix C. Simulation Assumptions and Thermal/Electrical Load Profiles 313
Appendix D. Electric wiring for Fuel cell micro-generation system tested at CCHT 321
Appendix E. Utility Rates 322
References for Appendix 324
[Back Cover] 325
Table 1. Summary of modeling cases 222
Table 2. Control strategies for boiler-chiller system (Case 1) 226
Table 3. Control strategies for GAHX-PVT-AWHP trigeneration system (Case 2) 227
Table 4. Breakdown of annual energy consumption/production for cases 1-2 in Incheon and Ottawa 230
Table 5. System performance (COP) for cases 1 and 2 in Incheon and Ottawa 233
Table 6. Breakdown of annual electricity generation and supply of GAHX-PVT-AWHP trigeneration... 235
Table 7. CO2eq emission factors used analyses for Incheon and Ottawa cases(이미지참조) 235
Table 8. Natural gas prices in Ottawa, Canada 237
Table 9. Ontario electricity time-of-use price periods and respective rates 238
Table 10. Electricity prices used in cost analyses for Ottawa cases 238
Table 11. Natural gas prices in Korea 238
Table 12. Electricity prices in Korea 239
Table 13. RMSE values of the validated TRNSYS PVT model 246
Table 14. RMSE values of the validated TRNSYS GAHX model 249
Table 15. Modified rated cooling capacity and power consumption for TRNSYS AWHP models 250
Table 16. Modified rated heating capacity and power consumption for TRNSYS AWHP models 253
Table 17. TTC testing scenarios and schedules for achieving different demand conditions 256
Table 18. Simulation cases for evaluating impact of reneweable components on energy performance 257
Table 19. Comparison of TTC and IWEC weather data 258
Table 20. CO₂ emission factors used analyses for Incheon and Ottawa cases 263
Table 21. Linguistic description of fuzzy logic system inputs and output for AWHP system 266
Table 22. Fuzzy inference system operators used in the study 267
Table 23. If-Then rules for AWHP operational state for FL controller with one input (FL-1) 267
Table 24. If-Then rules for AWHP operational state for FL controller with two inputs (FL-2) 268
Table 25. AWHP operational stage 270
Table 26. Electric energy savings achieved by FL controllers in different time-periods compared to an... 271
Table 27. Economic and emissions input parameters 279
Table 28. Optimization variables and boundaries 279
Table 29. Breakdown of Annual Optimum Cost for Trigeneration System 282
Table A1. Specification of Twin-Test-Cell facility located at KIER 301
Table A2. Performance Data for Air-to-Water Heat Pump 301
Table A3. PVT system performance 303
Table A4. Rehau Ecoair system performance 303
Table B1. Boiler efficiency at partial load 305
Table B2. Chiller capacity ratio and power ratio 306
Table B3. Chiller performance data at partial load 307
Table B4. Control strategies for boiler-chiller system (Case 1) 310
Table B5. Control strategies for GAHX-PVT-AWHP trigeneration system (Case 2) 311
Table B6. TRNSYS model types used in present simulations 311
Table C1. House building specification 314
Table C2. Infiltration rate of house and office 316
Table C3. Simulation period and weather data 317
Table C4. Main input parameters for Case 1 317
Table C5. Main input parameters for case 2 for single house 319
Table E1. Ontario electricity time-of-use price periods and respective rates 323
Table E2. Electricity prices used in cost analyses 323
Table E3. Natural gas prices used in Ottawa, Canada 323
Fig. 1. Schematic diagram of house with conventional system (Case 1) 222
Fig. 2. Schematic diagram of GAHX-PVT-AWHP trigeneration system (Case 2) 222
Fig. 3. Schematic layout of Twin-Test-Cell at KIER 223
Fig. 4. Schematic of TTC experimental setup 224
Fig. 5. Annual space heating, space cooling and DHW load intensity for cases 1 and 2 in Incheon and... 228
Fig. 6. Annual energy consumption/production intensity for cases 1 and 2 in Incheon and Ottawa 229
Fig. 7. Annual primary energy consumption intensity for cases 1 and 2 in Incheon and Ottawa 231
Fig. 8. Distribution of primary energy consumption by components for cases 1-2 in Incheon and... 232
Fig. 9. Overall primary energy saving of GAHX-PVT-AWHP trigeneration system in Incheon and... 233
Fig. 10. Sample PVT electricity production and building HVAC electric load for GAHX-PVT-AWHP... 234
Fig. 11. Annual CO2 emission intensity of cases 1-2 in Incheon and Ottawa 236
Fig. 12. Annual CO2 emission reduction of GAHX-PVT-AWHP trigeneration system in Incheon and... 236
Fig. 13. Annual operation cost intensity (CAD $/m2) for cases 1-2 in Incheon and Ottawa 239
Fig. 14. Annual operational cost comparisons of GAHX-PVT-AWHP trigeneration system to... 240
Fig. 15. Measured air inlet/outlet temperature, flowrate, ambient temperature and calculated... 244
Fig. 16. Measured solar irradiance and PVT electric intensity and calculated thermal intensity 244
Fig. 17. PVT electric and thermal efficiencies derived from experimental data in time-series 245
Fig. 18. Comparison of predicted and measured PVT air outlet temperature 245
Fig. 19. Comparison of predicted and measured PVT electric power 246
Fig. 20. Comparison of predicted and measured PVT thermal power 246
Fig. 21. Schematic of testing layout for ground-to-air heat exchangers 247
Fig. 22. Comparison of predicted and measured air outlet temperature from a ground-to-air heat... 248
Fig. 23. Comparison of predicted and measured air outlet temperature from a ground-to-air heat... 249
Fig. 24. Comparison of AWHP cooling capacity between TRNSYS model and experimental testing 250
Fig. 25. Comparison of AWHP power consumption in cooling mode between TRNSYS model and... 251
Fig. 26. Comparison of AWHP COP in cooling mode between TRNSYS model and experimental testing 251
Fig. 27. Measured AWHP temperatures, flow rates, power consumption and heating capacity 252
Fig. 28. Comparison of AWHP cooling capacity between TRNSYS model and experimental testing 253
Fig. 29. Comparison of AWHP power consumption in cooling mode between TRNSYS model and... 254
Fig. 30. Comparison of AWHP COP in cooling mode between TRNSYS model and experimental testing 254
Fig. 31. Thermal load of Target and Reference cells under different testing periods 258
Fig. 32. Thermal output from PVT and GAHX under different testing periods 259
Fig. 33. Electric and thermal efficiency of PVT under different testing periods 259
Fig. 34. Breakdown of system electricity consumption of trigeneration system and HP system under... 260
Fig. 35. Net electricity consumption under different testing conditions 260
Fig. 36. Electricity savings under different testing conditions 261
Fig. 37. Energy consumption of the conventional and renewable trigeneration system under different... 262
Fig. 38. Comparison of primary energy consumption of the conventional and renewable trigeneration... 263
Fig. 39. Comparison of CO2eq emission of the conventional and renewable trigeneration system under...(이미지참조) 264
Fig. 40. Membership functions of room temperature difference, ambient (outside) temperature and... 267
Fig. 41. Control surface for FL controller with one input in heating and cooling modes 268
Fig. 42. Control surface for FL controller with one input in heating and cooling modes 269
Fig. 43. Comparison of electric energy consumption of AWHP system with On-Off and fuzzy logic... 270
Fig. 44. Comparison of operational time and stage of AWHP system with On-Off and fuzzy logic... 271
Fig. 45. Flowchart system design optimization and simulation for Trigeneration System 276
Fig. 46. Outlet air temperature from GAHX at different outside temperature and GAHX length 277
Fig. 47. AWHP heat delivery to the load at different outside temperature and inlet water temperature... 278
Fig. 48. AWHP COP at different outside temperature and inlet water temperature in winter and... 278
Fig. 49. Hourly heating/cooling demand load and AWHP heat delivery for hybrid trigeneration system... 280
Fig. 50. Hourly HVAC and non-HVAC energy consumption, Energy production, CO₂ emissions and solar... 281
Fig. 51. Daily average energy consumption, production, and CO₂ emissions from hybrid trigeneration... 281
Fig. 52. Annual thermal demand loads and energy delivery for hybrid trigeneration system under... 282
Fig. 53. Breakdown of annual thermal energy delivery of the hybrid trigeneration system under... 283
Fig. 54. Annual electrical energy of the hybrid trigeneration system under optimum design conditions... 284
Fig. 55. Hybrid trigeneration system performance 284
Fig. A1. Twin-Test-Cell Layout 300
Fig. A2. Rehau Ecoair Ground loop system in summer and winter seasons 302
Fig. B1. Boiler with different efficiency characteristics 304
Fig. B2. Chiller performance at partial load 305
Fig. B3. Room thermostat set-points for house and office 309
Fig. C1. Internal gains of residential and office buildings 314
Fig. C2. Internal moisture gain of residential and office buildings 315
Fig. C3. Daily domestic hot water load profiles for house and office 315
Fig. D1. Schematic Diagram of the Upgraded Electric Wiring and Metering in the CCHT Houses 321
Fig. E1. Ontario Electricity Time-of Used price Periods 322